[bub]

Originally Posted by travislambert

A member asked me to post part #s so here it goes....

Keep in mind many of the '17 ZL1 parts were not available at the time I did my build so there might be more ideal parts available now. Also, I ordered my engine with the s/c belt, pulleys, heat exchanger, and supercharger inlet duct so unfortunately I don't have the numbers for these. Contact Greg Was at pace performance (gregwas@paceperformance.com) if you need these parts. Pace Performance is a GM parts dealer that sells parts as cheap as you'll find anywhere. (I am in no way affiliated with pace performance. I'm simply a happy customer.)

19332621 - LT4 Crate Engine (Wet Sump) - It comes with a very good intercooler pump (13597903). It also comes with the knock sensor heat shield it claims not to come with.
23117748 - LT4 Fuel line (Comes with plastic clips)
23455459 & 23455460 - Heat Exchanger Brackets (Left & Right, but I'm not sure which is which)
11570323 - Heat Exchanger Bracket Bolt - $3.66 each (x8)
23377187 - Brake booster vacuum line - This part doesn't actually fit, but you can use the connectors on it to make one that does.
13584423 - MAP Connector Pigtail - Some folks simply swap for an LS9 MAP without the IAT2. I bought this connector instead and ran a new wire for the IAT2 to the ECM.
12663963 - Evap Tube
84013640 - '17 ZL1 Radiator Hose Assembly - You can make the SS one work. There's not much difference, but it was worth the money to me to not have to fool with it.
12561465 - Clutch Pressure Plate Bolts - $.59 ea - (x6)
24268307 - '16 Z06 Clutch & Pressure Plate - $343.18
24255997 - '16 Z06 Flywheel - $601.03 (Same part # as '16 Camaro SS Flywheel) This comes with flywheel bolts.
12563485 - Flywheel bolts - $5.80 ea (x8) You'll need these if you are reusing your LT1 flywheel. Do not reuse the old bolts! They stretch when torqued.
12624939 - Exhaust Manifold to converter gasket - $7.36 x2
21992620 - Exhaust gasket (after passenger side converter) - $16.36 ea
12557583 - GM Roller Pilot Bearing - $11.34
19300589 - Coolant Pump Connector Pigtail - $50.32
12647125 - PCV hose
23385107 - Engine Wiring Harness for Camaro SS Manual with Magnetic Ride Control - $330.65
88988501 - Supercharger Bypass Connector Pigtail - $16.91
23296636 - Intercooler Hose
23424016 - Radiator Hose (Don't remember where this one goes)
11589264 - 2016 Camaro SS Exhaust manifold studs - $8.05 each. (x8) These can be reused, but are sometimes hard to remove so I just bought new ones.

Misc parts I ordered for intercooler plumbing
-----------------------------------------------
12670874 - Tube - $32.10
23424013 - Hose - $20.65
23424015 - Fitting - $32.99
11547667 - Hose Clamp - $2.40 (x3)
11570871 - Hose Clamp - $3.23 (x2)
11519385 - Bolt - $2.87 (x2)

Other stuff you'll probably need
--------------------------------
- Tesa 50126 Wiring Harness Tape (2 rolls should do fine) https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1

- Heat Exchanger

- ZL1 Jack Pads from https://www.zl1addons.com. I would buy 4 with the jack pads if you plan to use a lift. They're worth the money.

- PF64 Oil Filter and 11 quarts of oil (The first fill takes a little more than 10 quarts).

- A fused relay, wiring, and loom for the coolant pump. I used the Painless Wiring 30821 Hlite Relay Kit #37827 and modified it to work like a normal relay.

- Dexcool Coolant (2 gallons of concentrate and 2 gallons of distilled water will be plenty.)

- Fir Tree Push Mount cable ties. I used these: https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1

- A set of Push type retainer clips. The Swordfish 60010 kit has ones that match GM perfectly. https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1

- Loctite 242 and 272... A tiny bottle of each will work fine.

- A/C Vacuum Pump kit to recharge A/C System. I bought these and they worked great:

FJC (6909) 3.0 CFM Vacuum Pump - https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1
Mountain 8205 R-134a Brass Manifold Gauge Set with Couplers - https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1
Mountain 8401 Top Style Metal Can Tap - https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1
ACDelco 10-9097 R134A (I think you need 2 cans. I would get 3 just to be sure.) - https://www.amazon.com/gp/product/B0...?ie=UTF8&psc=1

- 19299818 - Brake and Clutch Fluid (FYI, to bleed the clutch on these you'll probably need to put a vacuum pump on the brake fluid reservoir. The bleeder is pretty much impossible to get to after the transmission is put back into the car.)

- Lots of time


Other Misc Stuff That You Probably Won't need
--------------------------------------
52474373 - A/C Compressor Seal - $4.20
12657093 - GM LT1, L83, L86 Exhaust Manifold Gasket - $4.03
11546600 - Exhaust manifold to engine bolt - $2.69 ea (x10)
11611992 - Supercharger lid bolt - $2.45
84044721 - Underhood fuse block (LT1) - $143.86
84063674 & 84063675 - Rear '17 SS 1LE Calipers - $240.00 each
12672471 - PCV Oil Separator - $80.04
12657430 - Water Manifold Gaskets - $2.48 ea (x2.)
12656725 - Engine Oil Cooler Line (Runs from the bottom of the water manifold to the rear of the engine oil cooler) - $50.42
23355791 – '17 SS 1LE Front Wheels 20 x 10 - $572.40 plus $50.00 core charge
23355802 - '17 SS 1LE Rear Wheels 20 x 11 - - $572.40 plus $50.00 core charge
23115614 - '17 SS 1LE Wheel Center Cap - $20.99 (x4)
13598786 (RPO code XL7 315mHz) or 13598787 (RPO code XL8 433mHz) - TPMS Sensor - $45.64 (x4)
24274085 - Clutch Slave Cylinder - $310.07
12644807 - LT4 MAP Sensor (just in case your engine comes with the wrong one like mine did)
12640390 - Knock Sensor Shield - $19.18 (The LT4 docs say you need to buy this, but mine came with it.)

What is the P/N of the front splitter for the 1LE? (color)?

[travislambert]

Originally Posted by bub

What is the P/N of the front splitter for the 1LE? (color)?

My car came with the fascia extension. I'm not sure if the SS 1LE uses the same extension I have or not. The one I have is the same one sold as an accessory:

http://www.chevrolet.com/camaro-spor...cessories.html

Click "GROUND EFFECTS - FRONT FASCIA"

I believe the black extension for the SS is #84116168

[LibertyHill]

Watched. Is there a substantial insurance cost difference between the SS and ZL1?

[travislambert]

Originally Posted by LibertyHill

Watched. Is there a substantial insurance cost difference between the SS and ZL1?

I'm not sure. I suppose I'll find out in March or April.

[travislambert]

I swapped the wheels, lowered the price, and relisted the car:
http://www.ebay.com/itm/222378324894

[i2disturbedSS]

So you are getting a ZL1?

Geez man if you can afford all this and take the hit why not. Seems like you got the sickness lol

This was my first time reading this thread and thought it was well done.

[travislambert]

Originally Posted by i2disturbedSS

So you are getting a ZL1?

Geez man if you can afford all this and take the hit why not. Seems like you got the sickness lol

This was my first time reading this thread and thought it was well done.

Yeah. My ZL1 order number is "VBJB3P". I'm supposedly #1 on the list at one of WV's highest volume dealers. So my fingers are crossed that my order will be accepted on the Feb 9th cycle.

Definitely have the sickness... or maybe it's the loss I'm taking on the SS... either way I feel sick... LOL

Thanks for the kind words. I'm certainly a little sad about selling the SS. It really is one hell of a car. I doubt the ZL1 will be as fast (initially), but I'm intrigued by some of the ZL1 gadgets.

[travislambert]

When I lowered the price on eBay the offers I was getting also went down. So I'm trying a new approach (I raised the asking price, but what I'm willing to take didn't change.).

http://www.ebay.com/itm/222385360442

[TenSeven]

...and here are my ONLY two passes:

60'............. 2.3022
1/8 mile........ 8.0801
1/8 mile mph.... 98.27
1/4 mile........ 12.10
1/4 mile mph.... 122.98

60'............. 2.2729
1/8 mile........ 8.0906
1/8 mile mph.... 97.64
1/4 mile........ 12.11
1/4 mile mph.... 123.29

Oh yeah, when the 60' times come down to 1.95-2.0 you'll have an 11.5 second car. Beautiful!

Very nice, the sleeper aspect is excellent. Hope you get the $$$'s you need for it.

[travislambert]

The car is still for sale on eBay. Here's the updated listing:

http://www.ebay.com/itm/222400038473

[trueraiderfan17]

Originally Posted by Capisce

Who let tony stark on the board? Between your gorgeous garage and crazy skills I think i have a man crush

[Diode Dynamics]

Good luck with the sale! Hopefully this car finds a good home

+1 on documenting this process for other members on the forum

Nick C.

[travislambert]

Sold!

[Chevy71]

Plans or a thread for your ZL1?